Product ID:4530S ADDITIVES FOR TOPCOATS
MSDS Date:01/01/1995
FSC:8010
NIIN:00F044573
MSDS Number: BYKNG

DU PONT E I DE NEMOURS & CO INC AUTOMOTIVE PRODS D

BRANDYWINE BLDG 3332 1007 MARKET ST
WILMINGTON, DE 19898-5000
US

Emergency Phone: 800-441-3637/800-441-7515

Info Phone: 800-441-7515/302-2774-9395

Preparer: T R LOUER

Cage: 90227

DU PONT E I DE NEMOURS & CO FABRICATED PROD DEPT

WILMINGTON, DE 19898 US

Telephone: 800-441-3637

Cage: 90227

BUTYL ACETATE (N-BUTYL ACETATE) *95-3*

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (IARC CARC- GROUP 3) *95-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 3%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-3*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

FATTY ACIDS, LINSEED OIL, REACTION PRODUCTS POLYMER;

CAS: 96591-17-2

SILICON DIOXIDE, CELITE 322, AMORPHOUS SILICA GEL *95-3*

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 80 MG/CUM

ACGIH TLV: 0.2 MG/CUM

SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH

CAS: 64742-95-6

RTECS: WF3400000

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY LEAD TO PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. EYES: MAY CAUSE IRRITATION &
BURNING. SKIN: MAY CAUSE IRRITATION W/DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, BURNING, DISCOMFORT.
SOLVENTS: EYE WATERING, HEADACHE, NAUSEA, DIZZINESS, LOSS OF
COORDINATION.

First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:CC
Flash Point:<73F
Lower Limits:0.9
Upper Limits:16
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE.
FINE MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP

Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
PREVENT SKIN CONTACT & BREATHING OF VAPORS. WEAR A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR. CONFINE & REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINERS AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F..
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS/MIST.

Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA DURING APPLICATION & UNTIL
VAPORS/MISTS ARE EXHAUSTED. CONFINED AREAS: WEAR A
POSITIVE-PRESSURE, SUPPLIED AIR RESPIRATOR. (SE E SUPP)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE
Eye Protection:SPLASH GUARDS/SIDE SHIELDS
Other Protective Equipment:NEOPRENE COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
RESPIRATORY PROTECTION CONT'D: DON'T PERMIT ANYONE W/O PROTECTION IN
THE PAINTING AREA.

Boiling Pt:B.P. Text:169-612F
Vapor Density:>1
VOC Grams/Liter:5.7
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:52-100

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO, CO2, SMOKE

Waste Disposal Methods:DON'T CONTAMINATE GROUND WATER SYSTEMS.
INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE
LIQUID UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.